Cars Chevrolet Lanos began rolling off assembly lines in 1997, and this one is still very compact, nimble, inexpensive car does not lose its relevance. The model is in demand due to its ease of maintenance and great endurance: due to the rigid suspension, the car, despite its sedan body, is distinguished by significant cross-country ability, and therefore is in demand even in rural areas with bad roads.
At the same Chevrolet time Lanos, which was supplied to Russia only in a sedan with an engine capacity of 1.5 liters and a power of 86 hp, ceased production in 2010, which, however, did not greatly reduce the demand for the car.
However, the years of the car are taking their toll, and Chevrolet repair Lanos is required quite often simply because cars are used intensively, and some components simply fail over time.
Chevrolet Lanos repair prices
The cost of the work must be agreed upon with the specialist over the phone!
| Service name | Price | ||
Maintenance of Chevrolet Lanos |
|||
| Replacement motor oil and oil filter | from 600 rub. | ||
| Replacement air filter | from 250 rub. | ||
| Replacing antifreeze | from 800 rub. | ||
| Replacing glow plugs | from 1750 rub. | ||
Diagnostics Chevrolet Lanos |
|||
| Checking the ignition system | from 950 rub. | ||
| Air conditioner diagnostics | from 800 rub. | ||
| ICE diagnostics | from 1000 rub. | ||
| Electronic diagnostics Examiner | from 800 rub. | ||
Chevrolet Lanos engine repair |
|||
| C/o engine | from 14,000 rub. | ||
| Cylinder head repair | from 25,000 rub. | ||
| Engine overhaul | from 40,000 rub. | ||
| Replacing engine mounts (mounts) | from 1200 rub. | ||
| Replacement front oil seal crankshaft | from 5600 rub. | ||
| Replacing the rear crankshaft oil seal when removed gearbox) | from 800 rub. | ||
| Removing/installing/replacing injectors high pressure | from 2000 rub. | ||
| Diagnostics fuel injectors high pressure on the stand (for 1 piece without water supply) | from 700 rub. | ||
| Removing/installing/replacing fuel injection pump | from 6000 rub. | ||
| Diagnostics of fuel injection pump on a stand (without c/o) | from 3500 rub. | ||
| Replacing the water pump (pump) (if removed belt timing) | from 1800 rub. | ||
Chevrolet Lanos suspension repair |
|||
| Replacement front shock absorber | from 1780 rub. | ||
| Replacing the front shock absorber support/pivot bearing/plate | from 1780 rub. | ||
| Replacing the front shock absorber spring | from 1780 rub. | ||
| Replacing racks front stabilizer(per pair) | from 700 rub. | ||
| Replacing front stabilizer bushings (per pair) | from 2500 rub. | ||
| Replacement front control arm | from 1500 rub. | ||
| Replacing front arm silent blocks (with removal) | from 1850 rub. | ||
| Replacing the ball joint | from 800 rub. | ||
| Replacement rear shock absorber | from 600 rub. | ||
| Replacing silent blocks of springs | from 4200 rub. | ||
| Replacing levers rear suspension | from 1500 rub. | ||
Chevrolet Lanos clutch repair |
|||
| Replacement of clutch assembly (2-shaft MGLU ABS-/ABS+) | from 8900/9400 rub. | ||
| Replacement of clutch assembly (3-shaft M38 ABS-/ABS+) | from 9300/9800 rub. | ||
| Replacing the left drive oil seal | from 1300 rub. | ||
| Replacing the right drive oil seal | from 1500 rub. | ||
Replacing the timing belt Chevrolet Lanos |
|||
| Replacing the timing belt for cars without air conditioning | from 4800 rub. | ||
| Replacing the timing belt for vehicles with air conditioning (without refilling the air conditioner) | from 5200 rub. | ||
| Replacement drive belt and rollers | from 1350 rub. | ||
Chevrolet Lanos generator repair |
|||
| Generator replacement | from 2500 rub. | ||
| Generator repair | from 2500 rub. | ||
Chevrolet Lanos power steering repair |
|||
| Changing power steering oil | from 750 rub. | ||
| Replacing the power steering pump | from 3000 rub. | ||
Chevrolet Lanos gearbox repair |
|||
| Changing gearbox oil | from 600 rub. | ||
| Removing and installing the ABS-/ABS+ gearbox | from 7900/8400 rub. | ||
| Gearbox repair | from 15,000 rub. | ||
Chevrolet Lanos starter repair |
|||
| Starter replacement | from 1500 rub. | ||
| Starter repair | from 2500 rub. | ||
Chevrolet Lanos brake system repair |
|||
| Replacement brake fluid(with pumping) | from 750 rub. | ||
| Replacing the front brake pads | from 780 rub. | ||
| Replacing the front brake discs | from 1280 rub. | ||
| Replacing the front brake caliper | from 1350 rub. | ||
| Replacing the main brake cylinder | from 1280 rub. | ||
| Replacing rear brake pads (Q15 - drums) | from 1520 rub. | ||
| Replacing rear brake pads (Q18 - discs) | from 980 rub. | ||
| Replacing rear brake drums | from 700 rub. | ||
| Replacing rear brake discs | from 1600 rub. | ||
| Q15 Rear Brake Cylinder Replacement | from 1300 rub. | ||
| Complete replacement rear brakes(pads, cylinders, extensions), including bleeding | from 2650 rub. | ||
| Q18 Rear Brake Caliper Replacement | from 1500 rub. | ||
| Replacing the cable hand brake(under the handle) | from 1200 rub. | ||
| Replacing the hand brake cable (on rear wheels Q15) | from 2250 rub. | ||
| Replacing the handbrake cable (rear wheels Q18) | from 2950 rub. | ||
| Prevention of anterior brake calipers(wc, replacement of anthers and lubrication of guides) | from 700 rub. | ||
| Maintenance of rear brake calipers (cleaning, replacement of anthers and lubrication of guides) | from 700 rub. | ||
Chevrolet Lanos chassis repair |
|||
| Replacing the front wheel bearing (without ABS) | from 2000 rub. | ||
| Replacing the front wheel bearing (with ABS) | from 2400 rub. | ||
| Bearing replacement rear hub Q15 | from 1400 rub. | ||
| Q18 Rear Wheel Bearing Replacement | from 1600 rub. | ||
| Replacing the left outer CV joint (or boot) | from 1500 rub. | ||
| Replacing the right outer CV joint (or boot) | from 1500 rub. | ||
| Replacement left internal CV joint(or anther) | from 1650 rub. | ||
| Replacing the right inner CV joint (or boot) | from 1850 rub. | ||
| Replacing the steering tip | from 450 rub. | ||
| Replacing the steering rod | from 650 rub. | ||
| Replacing the tie rod boot | from 500 rub. | ||
| Replacing the steering rack | from 3500 rub. | ||
Electrics Chevrolet Lanos |
|||
| Replacing a headlight bulb | from 580 rub. | ||
| Replacing a light bulb in a flashlight | from 250 rub. | ||
| Replacing PTF bulbs (for 2 pcs.) | from 500 rub. | ||
| Replacing the license plate light bulb | from 100 rub. | ||
Other Chevrolet Lanos |
|||
| Replacing the thermostat | from 2800 rub. | ||
| Replacing the cooling system radiator | from 2500 rub. | ||
| Replacing the cooling fan | from 1200 rub. | ||
| Replacing the windshield wiper trapezoid | from 1500 rub. | ||
| Replacement front motor windshield wiper | from 1550 rub. | ||
Common problems
The main problem that requires Chevrolet Lanos repair is the body. Despite its external attractiveness, it is not particularly durable, and therefore, if its integrity is damaged, active corrosion of the metal begins very quickly. Also among weaknesses This model can be noted:
- gearbox (deteriorates due to aggressive driving);
- bottom (repair is often required due to Low quality domestic roads);
- fuel pump (suffers due to low-quality fuel).
Where can I get a “Good” repair?
Our network of car service centers “Khoroshiy” is waiting for you professional specialists, which will quickly perform even complex repairs Chevrolet Lanos. We offer you work on specialized high-tech equipment and only with components from reliable suppliers. The cost of repairs will pleasantly surprise you. If any problem arises, we are waiting for you at the “Good” car services!
Fastening nuts and bolts checking tightening torque
1. Since the vibration to which the vehicle is exposed can cause loosening of the tightening torque of various fastening elements, such as bolts, nuts, screws, etc., it is necessary to periodically check the security of these elements.
2. Pay attention Special attention for the following components:
spark plug;
oil drain plug;
bolts for fastening vehicle controls, brake pedals, clutch and brake pedals;
engine mounting bolts;
bolts for securing shock absorbers and suspension arms.
Front suspension mounting bolt
rear suspension element mounting bolts;
fastening bolts brake mechanisms;
nuts/bolts securing the exhaust system.
3. If in stock torque wrench, tighten all fasteners to specifications.
Maintenance schedule
Designations:TO- control (i.e. if it is necessary to tighten, repair, lubricate, adjust, etc.)
Z- replace.
| Mileage, thousand km | 10 | 20 | 30 | 40 | 50 | 60 | 70 | 80 | 90 | 100 |
|---|---|---|---|---|---|---|---|---|---|---|
| Frequency, months | 12 | 24 | 36 | 48 | 60 | 72 | 84 | 96 | 108 | 120 |
| Job title | price | price | price | price | price | price | price | price | price | price |
| Changing the oil and oil filter | 500 | 500 | 500 | 500 | 500 | 500 | 500 | 500 | 500 | 500 |
| Changing the oil in manual transmission | I | I | I | I | I | I | I | I | I | I |
| Replacing spark plugs | I | 300 | I | 300 | I | 300 | I | 300 | I | 300 |
| Replacing the fuel filter | 500 | 500 | 500 | 500 | 500 | 500 | 500 | 500 | 500 | 500 |
| Replacing the air filter | 100 | 100 | 100 | 100 | 100 | 100 | 100 | 100 | 100 | 100 |
| Replacing brake fluid | I | I | 800 | I | I | 800 | I | I | 800 | I |
| Replacing the timing belt | 3500 | |||||||||
| Coolant replacement | I | I | I | 800 | I | I | I | 800 | I | I |
| Cost of work, rub. | 1100 | 1400 | 1900 | 2200 | 1100 | 5700 | 1100 | 2200 | 1900 | 1400 |
| Spare parts and materials | price | price | price | price | price | price | price | price | price | price |
| Motor oil | 2100 | 2100 | 2100 | 2100 | 2100 | 2100 | 2100 | 2100 | 2100 | 2100 |
| Oil filter | 300 | 300 | 300 | 300 | 300 | 300 | 300 | 300 | 300 | 300 |
| Timing belt + rollers | 4000 | |||||||||
| Air filter | 420 | 420 | 420 | 420 | 420 | 420 | 420 | 420 | 420 | 420 |
| Fuel filter | 510 | 510 | 510 | 510 | 510 | 510 | 510 | 510 | 510 | 510 |
| Candles (4pcs.) | 800 | 800 | 800 | 800 | 800 | |||||
| Antifreeze | 900 | 900 | ||||||||
| Brake fluid | 300 | 300 | 300 | |||||||
| Number of spare parts, rub | 3330 | 4130 | 3630 | 5030 | 3330 | 8430 | 3330 | 5030 | 3630 | 4130 |
| Total cost of maintenance, rub. | 4430 | 5530 | 5530 | 7230 | 4430 | 14130 | 4430 | 7230 | 5530 | 5530 |
Since 2002, Bers-Auto service center specialists have been producing repair and Maintenance chevrolet lanos. We have accumulated extensive experience working with these vehicles. Service masters constantly improve their knowledge, are certified, and have excellent knowledge specific features these machines. Our car service center carries out any type of work, from routine maintenance to suspension, engine, electrical or brake system car.
Need to make repairs chevrolet cars Lanos may appear suddenly, despite the sufficient reliability of these cars. In many ways an approximation repair work is related to how carefully the car is operated, and whether you bring it in for a scheduled inspection in a timely manner, how well you listen to your vehicle, noticing even the slightest suspicion of a malfunction.
Our service center for Korean and Japanese cars gives you a six-month guarantee for any type of work, and the highest level repairs Chevrolet Lanos in Moscow. Remember that the reliability of any vehicle directly depends on its timely and regularly scheduled diagnostics. To a greater extent, this applies to cars of the middle and lower segments, since their production often uses not very expensive components. It should also be emphasized that any repairs and diagnostics of the Chevrolet Lanos must be carried out in compliance with all the requirements and recommendations of the manufacturer. Every nuance concerning the operation of all components and assemblies of the car is written down in the service book, and all this must be observed.
The Chevrolet Lanos maintenance schedule involves a number of mandatory procedures that must be implemented depending on the mileage or time achieved. These recommendations, as we wrote above, are displayed in the service book, which is issued by the manufacturer for each car at the time of purchase. Of course, a lot will depend on the additional conditions under which your car is used. All these points should be displayed by you during your visit to the auto repair center.
Servicing a Chevrolet Lanos car includes not only visiting car repair shops, diagnosing and repairing them, but also everything that you do with it: this is the quality of the engine oil, the fuel that you pour into it, this is also careful driving, monitoring the condition of the interior , fuel and air filters, in other words, this is a huge number of nuances that need to be completed on time and at the proper level. If you treat your vehicle with care, show it to specialists every year, and carry out vehicle maintenance, then you will not need to expensive repairs, which will save you money and time.
Maintenance of Chevrolet Lanos at Bers-Auto is:
- quality;
- reliability;
- guarantees.
Designations:
- I - inspect, clean, correct, fill, adjust if necessary;
- R - replace;
- 1 - when operating in harsh conditions (frequent driving over short distances, frequent work on Idling, driving in dusty conditions) - change every 5000 km or every 3 months (whichever comes sooner).
Engine
| Engine assembly | Kilometers or time in months (whichever comes first) | |||||||||
|---|---|---|---|---|---|---|---|---|---|---|
| Kilometers, thousand km. | 10 | 20 | 30 | 40 | 50 | 60 | 70 | 80 | 90 | 100 |
| Months | 6 | 12 | 18 | 24 | 30 | 36 | 42 | 48 | 54 | 60 |
| Alternator drive belt, power steering | I | I | I | I | I | R | I | I | I | I |
| Motor oil and oil filter 1 | R | R | R | R | R | R | R | R | R | R |
| Cooling system and connecting hose socket | I | I | I | I | I | I | I | I | I | I |
| Coolant | I | I | I | R | I | I | I | R | I | I |
| Fuel filter | R | R | ||||||||
| Fuel hoses and connections | I | I | I | I | I | |||||
| Air filter | I | I | I | R | I | I | I | R | I | I |
| Setting the ignition timing | I | I | I | I | I | |||||
| Spark plug | I | R | I | R | I | R | I | R | I | R |
| DIS block | I | I | I | I | I | |||||
| PSV system | I | I | I | |||||||
| Camshaft belt | I | R | ||||||||
Chassis and body
- Exhaust pipe and its fastenings - inspection every 10 thousand km or 6 months;
- Brake fluid (clutch) 1 - replacement every 30 thousand km (18 months), inspection every 10 thousand km or 6 months;
- Rear brake drums and friction linings - replacement as they wear out, inspection every 10 thousand km or 6 months;
- Front brake linings and discs - replace as they wear out, inspect every 10 thousand km or 6 months;
- Hand brake - replacement as it wears out, inspection every 10 thousand km or 6 months;
- Brake cable and connections - replace as they wear out, inspect every 10 thousand km or 6 months;
- Rear wheel bearing and clearance - replace when worn, inspect every 10 thousand km or 6 months;
- Oil manual box gears - replacement as they wear out, inspection every 10 thousand km or 6 months;
- Liquid and filter in automatic transmission gears require replacement when operating a car in the city with strong movement at air temperatures above 32° and above, when driving in hilly terrain, with frequent use of a trailer, when using a car as a taxi. Using a car under any such conditions requires changing the fluid and filter every 75,000 km;
- Free play of the clutch pedal - adjustment according to wear, inspection every 10 thousand km or 6 months;
- Tightening the bolts and nuts of the underbody chassis - replacement as they wear out, inspection every 10 thousand km or 6 months;
- Condition of tires and tire pressure - daily before leaving the car;
- Steering wheel, connections, power steering fluid - replace when worn, inspect every 10 thousand km or 6 months.
